Lehr 5.0 HP 4-STROKE Manuel d'utilisateur

LEHR | ALL RIGHTS RESERVED 2010-2011TABLE OF CONTENTSFOR SERVICE Call 1-866-941-LEHR (5347)5 HPMODEL: LP 5.0SLP 5.0LOPERATOR’S MANUALPROPANE POWERED

LEHR | ALL RIGHTS RESERVED 2012-20138OPERATIONPRE-OPERATION CHECKSWARNING: If anything in the pre-operation check is not working properly, have it in

LEHR | ALL RIGHTS RESERVED 2012-20139OPERATIONINSTALLING THE PROPANE CANISTER1. Make sure the engine is off.2. If the propane canister to be insta

LEHR | ALL RIGHTS RESERVED 2012-201310OPERATIONSTARTING ENGINE1. Place the gear shift lever in neutral. The engine is equipped with a lockout which

LEHR | ALL RIGHTS RESERVED 2012-201311OPERATIONSHIFTINGWARNING: Before shifting, make sure no swimmers are in the water near your boat.1. Place the

TILTING UP AND DOWNIf the engine will be stopped for some time and the boat is moored in shallows, the outboard motor should be tilted up to protect

LEHR | ALL RIGHTS RESERVED 2012-201313 MAINTENANCECARRY FROM THE HANDLESSTORE WITH THE HANDLE SIDE DOWNTRANSPORTING AND STORING THE OUTBOARD MOTORWAR

LEHR | ALL RIGHTS RESERVED 2012-201314MAINTENANCESTORING THE OUTBOARD MOTORNOTE: Place a towel or something similar under the outboard motor to prote

LEHR | ALL RIGHTS RESERVED 2012-201315MAINTENANCEInitial EveryItem Actions10 hours 50 hours 100 hours 200 hours(1month)(3months)( 6 months)(1 year)An

LEHR | ALL RIGHTS RESERVED 2012-201316MAINTENANCEGREASINGNOTE: Use only water resistant grease.Grease in these areas:Spark plug gap:0.020-0.024in (0.

LEHR | ALL RIGHTS RESERVED 2012-201317ADJUSTING IDLING SPEEDWARNING: Do not touch or remove electrical parts when starting or during operation. Kee

* Green Key- is a trademark of the Coleman company WARNING: PROPANE IS HIGHLY FLAMMABLE, AND ITS VAPORS CAN EXPLODE IF IGNITED. SAFETY WARNINGS FOR P

LEHR | ALL RIGHTS RESERVED 2012-201318MAINTENANCE5. Make sure that there are no oil leaks. Continued operation with an oil leak could cause severe

LEHR | ALL RIGHTS RESERVED 2012-201319INSTALLING THE PROPELLER• Be sure to install the thrust washer before installing the propeller, otherwise the l

LEHR | ALL RIGHTS RESERVED 2012-201320MAINTENANCERecommendedgearoil:HypoidgearoilSAE#90Gearoilquantity:2.54 US fl. oz. (75.0 mL)CHANGING GEAR OIL• Be

LEHR | ALL RIGHTS RESERVED 2012-201321TROUBLESHOOTINGA problem in the fuel, compression, or ignition systems can cause poor starting, loss of power,

LEHR | ALL RIGHTS RESERVED 2012-201322TROUBLESHOOTINGQ: Is trim angle correct?A: Adjust trim angle to achieve most efficient operation.Q: Is motor mo

LEHR | ALL RIGHTS RESERVED 2012-201323TROUBLESHOOTINGEMERGENCY ENGINE START1. Remove the top engine cover.2. Remove the starter cover by unscrewing

LEHR | ALL RIGHTS RESERVED 2012-201324SPECIFICATIONSMODELS LP 5.0S & LP 5.0LENGINE TYPEWATER COOLED 4-CYCLEDISPLACEMENT112.0 CC *ALL SPECIFICATIO

LEHR | ALL RIGHTS RESERVED 2012-201325The limited warranty set forth below is given by LEHR with respect to new merchandise purchased and used in the

LEHR | ALL RIGHTS RESERVED 2012-201326MANUFACTURER’S LIMITED WARRANTY (10) Add-on or modified parts that are not exempted by the Air Resources Bo

LEHR | ALL RIGHTS RESERVED 2012-201327 NOTES

LEHR | ALL RIGHTS RESERVED 2012-20131TO THE OWNERThank you for purchasing a LEHR propane outboard engine. This operator’s manual explains informa

One Star – Low Emission The one-star label identies Personal Watercraft, Outboard, Sterndrive and Inboard e

LEHR | ALL RIGHTS RESERVED 2012-20132GENERAL INFORMATION• Before mounting or operating the outboard motor, completely read manual and labels. Readin

LEHR | ALL RIGHTS RESERVED 2012-20133GENERAL INFORMATIONSERIAL NUMBER EMISSIONS LABEL WARNING LABELBASIC COMPONENTSNOTE: May not be exactly as shown,

LEHR | ALL RIGHTS RESERVED 2012-20134GENERAL INFORMATIONFUEL TANKUse a standard 16.4 oz. (1 lb.) propane canister connected to the rear propane tank

LEHR | ALL RIGHTS RESERVED 2012-20135GENERAL INFORMATIONWARNING: Do not overtighten the throttle friction adjuster. If there is too much resistance,

LEHR | ALL RIGHTS RESERVED 2012-20136GENERAL INFORMATIONTRIM ROD The position of the trim rod determines the angle of the outboard motor in relation

LEHR | ALL RIGHTS RESERVED 2012-20137INSTALLATIONINSTALLATIONIncorrect engine height or obstructions to smooth water flow in front of the propeller c